19 – 22 September 2017
Kuala Lumpur





In order to reduce vehicle exhaust emissions and save fuel, most of well-known car manufacturers are gradually introducing the micro-hybrid (start–stop) vehicles. These vehicles achieve better fuel economy with lower exhaust emissions and a lower cost. There are currently two types of start–stop batteries, namely, the enhanced flooded design (EFB) and the absorptive glass-mat (AGM) design. It has been forecast that there will be a rapid growth of AGM batteries, while such increase will occur for EFB batteries in 2018 and overtake AGM batteries 2 years later. Compared with AGM batteries, EFBs display better performance in terms of cold-cranking, charge-acceptance, but inferior deep cycle-life and cycle-life under partial state-of-charge duty. Consequently, this presentation describes studies to solve the above shortcomings of the EFB through continuous selection, optimization and improvement of paste additives. The experimental campaign has resulted in the successful development of a new generation of paste additives that significantly improve the cold-cranking, charge-acceptance and cycle-life performance of EFBs.

Shounan Hua
Shandong Jinkeli Power Sources Technology Co., Ltd.
Chief Consultant

Professor Shounan Hua graduated from Shandong University in1961 and was awarded a postgraduate degree by the same University in 1964. Since then, he has been engaged in teaching and researching activities in electrochemistry and chemical power source systems at Shandong University. From 1980 to 1982, he was a visiting researcher at CSIRO (with Dr Ron Woods and Dr David Rand in Melbourne, Australia), and in 1996 was a visiting scholar at the Juelich Research Center (Germany). Currently, Shounan is an Emeritus Professor at Shandong University and is also conducting research on lead–acid batteries as a consultant for Jinkeli.